Environmental and Health Issues | p. 1 |
Learning Objectives | p. 1 |
Key Terms | p. 1 |
Occupational Safety and Health Act | p. 2 |
Hazardous Waste | p. 2 |
Resource Conservation and Recovery Act (RCRA) | p. 2 |
Clean Air Act | p. 3 |
Material Safety Data Sheets (MSDS) | p. 3 |
The Dangers of Exposure to Asbestos | p. 3 |
Asbestos OSHA Standards | p. 4 |
Asbestos EPA Regulations | p. 4 |
Asbestos Handling Guidelines | p. 4 |
Used Brake Fluid | p. 4 |
Used Oil | p. 5 |
Disposal of Used Oil | p. 5 |
Used Oil Storage | p. 5 |
Solvents | p. 6 |
Solvent Hazardous and Regulatory Status | p. 7 |
Used Solvents | p. 7 |
Coolant Disposal | p. 7 |
Lead-Acid Battery Waste | p. 8 |
Battery Hazardous and Regulatory Status | p. 8 |
Battery Handling and Storage | p. 8 |
Fuel Safety and Storage | p. 8 |
Airbag Handling | p. 9 |
Used Tire Disposal | p. 9 |
Air-Conditioning Refrigerant Oil Disposal | p. 10 |
Measurement and Calculators | p. 15 |
Learning Objectives | p. 15 |
Key Terms | p. 15 |
Metric Measurement System | p. 16 |
Scientific Calculator and Scientific Notation | p. 17 |
Electronic Service Tools (EST) | p. 21 |
Learning Objectives | p. 21 |
Key Terms | p. 21 |
Analog Meters | p. 22 |
Basic Digital Multimeter (DMM) Design | p. 23 |
Electrical Units of Measurement | p. 24 |
Fluke 87/88 DMM Components | p. 26 |
Voltmeters | p. 27 |
Ammeter | p. 33 |
Ohmmeter | p. 35 |
Graphing Multimeters (GMM) | p. 37 |
Oscilloscope | p. 38 |
General Electrical Diagnosis | p. 51 |
Learning Objectives | p. 51 |
Key Terms | p. 51 |
Tracing Specific Circuits | p. 52 |
Service Information Sources | p. 59 |
Diagnostic Strategies | p. 61 |
Strategy-Based Diagnostics | p. 64 |
Basic Circuit Faults | p. 67 |
Simple Test Devices | p. 69 |
Scan Tool | p. 74 |
Circuit Protection and Component Testing | p. 81 |
Learning Objectives | p. 81 |
Key Terms | p. 81 |
Circuit Protection | p. 81 |
Circuit Components | p. 82 |
Testing for Circuit Defects | p. 87 |
Basic Circuit Law Review | p. 90 |
Wire and Connector Service and Repair | p. 101 |
Learning Objectives | p. 101 |
Key Terms | p. 101 |
Safety | p. 101 |
Tools and Supplies | p. 102 |
Repair Methods | p. 102 |
Connector Repair | p. 107 |
Battery Diagnosis and Testing | p. 121 |
Learning Objectives | p. 121 |
Key Terms | p. 121 |
Battery Safety | p. 122 |
Inspection, Cleaning, and Replacement | p. 123 |
Battery Testing | p. 128 |
State-of-Charge Test | p. 128 |
Capacity (Load) Test | p. 130 |
Parasitic Loss Testing | p. 133 |
Restoring Battery Memory Functions | p. 133 |
Battery Charging | p. 133 |
Battery Cable Service | p. 135 |
Jump Starting | p. 136 |
Charging System Diagnosis and Repair | p. 155 |
Learning Objectives | p. 155 |
Key Terms | p. 155 |
Inspection, Diagnosis, and Testing | p. 156 |
Drive Belt Service | p. 164 |
Voltage Regulator Service | p. 170 |
Testing Specific AC Generators | p. 171 |
AC Generator Removal | p. 182 |
Disassembly, Cleaning, and Inspection | p. 183 |
Bench Tests | p. 184 |
AC Generator (Alternator) Installation | p. 188 |
AC Generator (Alternator) Overhaul Procedures | p. 189 |
Starting System Diagnosis and Repair | p. 211 |
Learning Objectives | p. 211 |
Key Terms | p. 211 |
Inspection and Diagnosis | p. 212 |
Testing | p. 213 |
Starter Control Circuit Devices | p. 218 |
Starter Removal | p. 224 |
Bench Tests | p. 225 |
Disassembly, Cleaning, and Inspection | p. 228 |
Unit Installation | p. 233 |
Starter Motor Overhaul Procedures | p. 233 |
Electronic Diagnosis Using Electronic Service Tools (EST) | p. 251 |
Learning Objectives | p. 251 |
Key Terms | p. 251 |
DMM Features | p. 251 |
DMM Use | p. 252 |
Current Probe Accessories | p. 253 |
Typical DMM Tests | p. 253 |
Testing Semiconductors | p. 258 |
OEM Service Manual Diagnostic Procedure | p. 259 |
Ignition System Inspection, Diagnosis, Testing, and Distributor Service | p. 263 |
Learning Objectives | p. 263 |
Ignition Service Safety | p. 263 |
Inspection and Diagnosis | p. 264 |
Primary Supply Circuit Service | p. 264 |
Oscilloscope Diagnosis | p. 265 |
Oscilloscope Settings and Connections | p. 266 |
Primary Supply Circuit Service | p. 279 |
Ignition Control Module Service | p. 280 |
Speed and Reference Sensor Service | p. 283 |
Secondary Ignition Service | p. 287 |
Ignition Cable Service | p. 288 |
Distributor Cap and Rotor Service | p. 289 |
Spark Plug Service | p. 290 |
Distributor Service | p. 294 |
Distributor Removal and Inspection | p. 294 |
Distributor Installation | p. 297 |
Lighting System Diagnosis and Repair | p. 299 |
Learning Objectives | p. 299 |
Key Terms | p. 299 |
Lighting System Diagnosis | p. 299 |
Headlight Service | p. 300 |
Small Bulb Replacement | p. 313 |
Gauges, Warning Devices, and Driver Information Diagnosis and Repair | p. 325 |
Learning Objectives | p. 325 |
Key Terms | p. 325 |
Gauges | p. 325 |
Warning Lamps | p. 328 |
Electronic Digital Instrument Clusters | p. 329 |
Driver Information Centers | p. 330 |
Compass | p. 330 |
Coolant Fan Temperature Switch | p. 330 |
Horns, Wiper, and Washer Diagnosis and Repair | p. 335 |
Learning Objectives | p. 335 |
Key Terms | p. 335 |
Horn System | p. 335 |
Horn System Diagnosis and Repair | p. 336 |
Windshield Wiper and Washer Diagnosis and Repair | p. 338 |
Body Accessory Systems Diagnosis | p. 351 |
Learning Objectives | p. 351 |
Key Terms | p. 351 |
Supplemental Restraint System (SRS) | p. 352 |
Seat Belts | p. 356 |
Antitheft Systems | p. 358 |
Air-Conditioning (AC) And Heating Systems | p. 359 |
Audio Systems | p. 363 |
Cigarette Lighter or Power Receptacle | p. 366 |
Clock | p. 366 |
Cruise Control Systems | p. 366 |
Heated Side-View Mirror Systems | p. 368 |
Heated Seats | p. 369 |
Heated Windshield | p. 369 |
Keyless Entry System | p. 370 |
Power Lock and Latch Systems | p. 371 |
Power Seat Systems | p. 374 |
Power Sunroof and Convertible Top | p. 375 |
Power Window Systems | p. 376 |
Rear-Window Defroster Systems | p. 377 |
ASE Technician Certification Sample Test | p. 389 |
Natef Standards | p. 395 |
Index | p. 401 |
Table of Contents provided by Ingram. All Rights Reserved. |